久久久久亚洲AV成人无码-国产美女久久精品香蕉69-国产综合久久久久久鬼色-久久这里只有精品18-亚洲女久久久噜噜噜熟女,亚洲精品色婷婷在线影院,亚洲一区在线二区,天堂中文在线资源库用,国产内谢xxxxxxxhd,亚洲中文字幕在线精品 ,国产一区 国产精品 精品三_国产精品一区二区久久宅男_国产亚洲美女精品2020久久久_91精品国产自产在线观看永久 ,久久久精品成人免费观看国产下-91精品人妻一区二区三区蜜桃-亚洲午夜精品专区国产-国产福利一区二区三区高清

行業新聞

當前位置:首頁 > 新聞中心 > 行業新聞

空壓機自動排氣閥失靈的原因

來源:http://556rte.cn/   日期:2021-03-25   瀏覽量:0
TAG:山東制氮機,山東干燥機,山東螺桿鼓風機,山東空壓機,山東自動排水器

空壓機的起停通常由氣壓自動開關(氣壓繼電器)直接帶動交流接觸器對電動機實現自動控制。而氣壓自動開關大多數采用機械式結構,利用彈簧壓縮與釋放能量操動觸點。也許是氣壓自動開關的先天缺乏或因調節不當、機震等不同原因的影響。

The start and stop of the air compressor is usually controlled by the air pressure automatic switch (air pressure relay) directly driving the AC contactor to realize the automatic control of the motor. Most of the pneumatic automatic switches adopt mechanical structure, and use spring to compress and release energy to operate the contacts. It may be due to the congenital lack of air pressure automatic switch or the influence of improper adjustment, mechanical shock and other different reasons.

空壓機一般沒有自動排氣裝置。停機后自動排氣降壓,當氣壓達到設定壓力時。預置下次空載起動,排氣閥失靈后,空壓機缸內氣壓不能釋放,等于電動機帶載起動,可能造成起動困難或堵轉故障。

20210325840616.jpg

Air compressor generally does not have automatic exhaust device. After shutdown, exhaust and depressurize automatically, when the air pressure reaches the set pressure. If the exhaust valve fails, the air pressure in the air compressor cylinder can not be released, which means that the motor starts with load, which may cause starting difficulty or locked rotor fault.

運行中突遇停送電:自動檔控制的空壓機,遇到突然間停送電情況(如市電,自備電電源轉換)由于空壓機缸內氣壓來不及釋放又重新啟動。電動機處于重載起動,很可能形成堵轉故障。過于頻繁起動:因外圍用氣量不規則,用氣量大時,迫使電動機作頻繁起動工作。起動時大電流產生的熱余量積累不易散發,使電動機溫升過熱,很可能造成電動機燒毀。

Sudden power cut-off during operation: the air compressor controlled by automatic gear will be restarted in case of sudden power cut-off (such as power supply, self-contained power supply conversion) because the air pressure in the air compressor cylinder is too late to release. When the motor starts under heavy load, it is likely to cause locked rotor fault. Too frequent starting: due to the irregular peripheral gas consumption, when the gas consumption is large, the motor is forced to start frequently. When starting, the accumulation of heat allowance caused by large current is not easy to disperse, which makes the temperature rise of the motor overheat and may cause the motor to burn down.

重負荷停機:空壓機的停機,與其他設備不同,都是達到設定上限最大壓力時停機。交流接觸器在接受重負荷、大電流下分段動作。此時拉弧火花最為嚴重,對交流接觸器損壞造成很大威脅,由于交流接觸器損壞,將引發電源性質故障。如不平衡(缺相)等運行狀態。

Heavy load shutdown: the shutdown of air compressor, different from other equipment, is to stop when the maximum pressure reaches the set upper limit. Under heavy load, the AC contactor operates in sections. At this time, the arc spark is the most serious, which poses a great threat to the damage of AC contactor. The damage of AC contactor will lead to power failure. Such as unbalanced (lack of phase), etc.

螺桿式空壓機自身機械性質故障:空壓機是不均勻負荷性質,機震噪聲大,傳動機件受阻引起磨損損壞等機械性故障,極容易引起電動機過載(堵轉、阻塞等)

Screw air compressor mechanical property fault: the air compressor is uneven load property, mechanical vibration noise, transmission parts blocked caused by wear damage and other mechanical faults, it is very easy to cause motor overload (locked rotor, blocking, etc.)


上一篇:消聲器,壓縮空氣自動排水器的原理及種類。
下一篇:淺析制氮機主機中儲氣罐的作用

宁波市| 达拉特旗| 辽中县| 绩溪县| 汉沽区| 四会市| 如皋市| 玉田县| 万宁市| 呼和浩特市| 和静县| 陆良县| 舟曲县| 中山市| 汉中市| 绵竹市| 普格县| 乌拉特中旗| 承德市| 屯昌县| 桐城市| 嘉定区| 沁源县| 错那县| 武强县| 灵山县| 宁阳县| 若羌县| 繁昌县| 桐城市| 孝昌县| 延川县| 黄骅市| 滦南县| 阳高县| 台安县| 牡丹江市| 金山区| 平定县| 金湖县| 科尔|